SECTION

FUELING

/!\

WARNING:

Use

only crystal clear kerosene (Red dyed

clear kerosene

or low

sulphur

oil). Neber

use

gasoline, white gas, camp fuel

other flammable liquids.

Use of

such Fuels

can

result

in an

explosive

fire

and

cause severe injury.

FUELING OPTIONS AVAILABLE

Fueling

your Monitor 2400 Heating System

can be

accomplished

in one of 2

ways:

Gravity

Fed

Large Capacity External Tank:

Practical

for

large heating needs where bulk delivery

kerosene

available. This system should

installed

by a

qualified plumber

fuel supply

technician.

Large

Capacity

External Tank

with

Pump:

For

large heating needs where

gravity

fed

system

not

practical.

electric lifter pump, especially

designed

for use

with

your

Monitor

2400

heating

system,

available

from

your dealer.

When

using

gravity

fed

tank

pumping system

supply

fuel,

the

inlet

pressure

to the

heater must

not

exceed

2.5

psi.

NOTE:lt

recmmended

install

the

fuel

line

on the

left

side

of the

unit,

with

appropriate

shut-off

valve,

and

then

across,

behind

the

unit,

to the

attachment

point

on the

right

rear

of the

heater.

EXTERNAL

TANK

INSTALLATION-

Gravity

Fed

NOTE:External

tank

installations

must

comply

with

the

National

Fire

Prtection

Association

code

NFPA

locally applicable codes, such

as the

Uniform

Mechanical

Code,

that

are

cnsistent

with

NFPA

31.

Check

with

your

local

building

official.

install

large capacity, gravity

fed

external tank,

the

instructions below,

and

refer

Figure

21 for

one

possible

installation.

Use of a

qualified installer

recommended.

•

Installation

height

of the

bottom

of the

fuel

tank

should

be 16

inches

more above

the

floor surface

which

the

heater stands. This ensures that

inlet

fuel pressure

will

sufficient.

• The top of the

fuel

tank

should

be no

higher than

8>2

feet above

the

floor under

the

heater. Heights

above

8/4

feet will exceed

the 2.5 psi

inlet limit,

and

pressure reducer will need

to be

installed

near

the

unit.

•

The

horizontal length

piping should

not

exceed

100

feet

and

should

free

sharp bends

obstructions.

•

Piping should

include

inverse

U-type

bends

(to

avoid

air

locks,

which

could

block

the

fuel supply).

•

Only

inch

copper

tubing

should

used.

The

tubing

should

bent carefully

avoid crimping.

• A

fuel

filter

recommended

for use on the

fuel line

near

the

tank,

and a

shut-off valve should

installed

at the

tank.

• A

flare adaptor

can be

used

make

flared tubing

connection between

the

unit

and the

filter

at the

tank.

• The

fuel tank should

located

closer than

feet

to a

source

heat.

•

The

fuel

tank

should have

opening

for

filling

the top and

vent

with

weather-proof

cap on the

side.

some tanks

the

vent

and

fill

spout

use the

same opening.

When using

gravity

fed

tank

supply fuel,

the

inlet

pressure

to the

heater must

not

exceed

2.5

psi.

The

Monitor 2400 comes equipped with

/a"

pipe

thread

connection.

straight,

or 90

degree

pipe-to-

flare

fitting

or a

firomatic

valve

can be

used

for the

fuel line connection.

If a

firomatic valve

being

used:

Valve

Position-Open/Close

Turn counterclockwise

open, clockwise

close.

threaded

valve stem

sticking

about

valve

open.

handle screws

off

stem, valve

closed.

1 2 ... 12 13 14 15 16 17 18 19 20 21 22 ... 26 27

Commenti su questo manuale

Nessun commento

Wheatheart WHR 130 x 51-71ft Augers PTO Handbücher

Bedienungsanleitungen und Benutzerhandbücher für Spezialmaschinen Wheatheart WHR 130 x 51-71ft Augers PTO.
Wir stellen 1 PDF-Handbücher Wheatheart WHR 130 x 51-71ft Augers PTO zum kostenlosen herunterladen nach Dokumenttypen zur Verfügung Bedienungsanleitung

Wheatheart WHR 130 x 51-71ft Augers PTO Bedienungsanleitung (48 Seiten)

Marke: Wheatheart | Kategorie: Special machinery | Größe: 1.83 MB |

Inhaltsverzeichnis

PTO DRIVE MODELS

TABLE OF CONTENTS

1.Introduction

6 30662 R1

2.Safety First

2.1. GENERAL SAFETY

2.2. ASSEMBLY SAFETY

2.5. PTO SAFETY

2.6. HYDRAULIC SAFETY

2.7. OPERATIONAL SAFETY

2.8. MAINTENANCE SAFETY

2.9. SAFETY DECALS

Figure 2.2

Figure 2.3

16 30662 R1

3.Assembly

18 30662 R1

Auger Track Stop

51’ 1st set of holes from top

61’ 2nd set of holes from top

71’ 3rd set of holes from top

3.3. INTAKE HITCH

3.4. MULTI-STAGE DRIVESHAFT

3.5. SHAFT DRIVE GEARBOX

3.6. DRIVESHAFT SHIELD

3.7. DISCHARGE SPOUT

3.8. TRUSS

3.8. TRUSS GRAIN AUGERS SD

24 30662 R1

Figure 3.11

3.9. TRANSPORT UNDERCARRIAGE

30662 R1 27

28 30662 R1

30662 R1 29

30 30662 R1

30662 R1 31

3.12. PTO DRIVELINE

3.14. PLASTIC MANUAL HOLDER

3.15. MODEL DECAL PLACEMENT

34 30662 R1

4.Transport & Placement

4.2. PLACEMENT PROCEDURE

30662 R1 37

38 30662 R1

5.Operation

5.3. OPERATING PROCEDURE

ORMAL SHUTDOWN:

MERGENCY / FULL-TUBE RESTART:

LOWERING

Area Maintenance Frequency

44 30662 R1

7.Troubleshooting

GRAIN AUGERS SD

46 30662 R1

LIMITED WARRANTY

Weitere Produkte und Handbücher für Spezialmaschinen Wheatheart

Modelle	Dokumententyp
GHR Auger Wheel Kit	Bedienungsanleitung Wheatheart GHR Auger Wheel Kit User Manual, 16 Seiten
R Series Augers	Bedienungsanleitung Wheatheart R Series Augers User Manual, 46 Seiten
X160 Series	Bedienungsanleitung Wheatheart X160 Series User Manual, 146 Seiten
Post Pounder	Bedienungsanleitung Wheatheart Post Pounder User Manual, 44 Seiten
S2000 Post Pounder	Bedienungsanleitung Wheatheart S2000 Post Pounder User Manual, 58 Seiten
Self-Propelled Post Pounder Kit	Bedienungsanleitung Wheatheart Self-Propelled Post Pounder Kit User Manual, 36 Seiten
Livestock Waterer	Bedienungsanleitung Wheatheart Livestock Waterer User Manual, 28 Seiten

Monitor M2400 Specifiche Pagina 17

Commenti su questo manuale

Prodotti e manuali riguardandi no Monitor M2400

Wheatheart WHR 130 x 51-71ft Augers PTO Handbücher

Wheatheart WHR 130 x 51-71ft Augers PTO Bedienungsanleitung (48 Seiten)

Inhaltsverzeichnis

Weitere Produkte und Handbücher für Spezialmaschinen Wheatheart